| ARTICLE TITLE | ARTICLE NO. | MODEL YEAR |
| 99 | 00 | 01 | 02 | 03 | 04 | 05 |
| F-250 through F-550 |
| WELD BONDING PROCEDURE |
04-26-16 (13 KB) |
| | | | | | X |
| CLUNK OR BUMP WHEN STARTING FROM A STOP |
04-26-06 (7 KB) |
X | X | X | X | X | X | X |
| WARNING INDICATORS - PARKING AID - REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS) - FALSE ACTIVATION OF WARNING TONE - SERVICE TIPS |
04-26-02 (21 KB) |
| | X | X | X | X | |
| STEERING WHEEL OSCILLATION (BACK AND FORTH MOTION) AFTER RIDING OVER BUMPS/RUTS |
04-26-01 (13 KB) |
| | | | | | X |
| CRANK NO START, HARD START, RUNS ROUGH AT IDLE - 6.0L |
04-25-18 (7 KB) |
| | | | | | X |
| MIL ILLUMINATED WITH DTC P0756, P0761 OR P0771 AFTER OVERHAUL OR INSTALLATION OF 2005 TORQSHIFT TRANSMISSION |
04-25-16 (6 KB) |
| | | | X | X | |
| HARD START OR NO START - 7.3L |
04-25-04 (33 KB) |
| X | X | X | X | | |
| LOSS OF POWER OR STUMBLE WHILE DRIVING IN RAIN - 6.8L ENGINE |
04-24-22 (80 KB) |
X | X | X | X | X | X | |
| SAFETY BELT RETRACTION SPEED |
04-24-21 (10 KB) |
| X | X | X | X | X | X |
| GENERAL PCM PROGRAMMING PROCEDURES |
04-24-14 (10 KB) |
X | X | X | X | X | X | X |
| MOMENTARY RETURN TO IDLE DURING AGGRESSIVE ACCELERATION - DIAGNOSTIC TROUBLE CODE (DTC) P0123 - 7.3L ENGINE |
04-24-11 (7 KB) |
| | X | X | X | | |
| LEATHER-WRAPPED STEERING WHEEL - LEATHER COMING LOOSE |
04-24-03 (7 KB) |
X | X | X | X | X | X | X |
| WATER LEAK - ROOF FLANGE AREA - WATER ACCUMULATION IN HEADLINER AND/OR LEAK AT THE CAB FLOOR PAN AREA |
04-23-09 (36 KB) |
X | X | X | X | X | X | X |
| STEERING GEAR NOISE - 6.0L DIESEL ENGINE |
04-23-08 (108 KB) |
| | | | | X | |
| VEHICLE LEAN/SAG WHEN OBSERVED FROM REAR OF VEHICLE |
04-23-06 (54 KB) |
X | X | X | X | X | X | X |
| MISFIRE, LACK OF POWER, BUCK/JERK, EXCESSIVE SMOKE, CRANK/NO START - 6.0L ENGINE - DIAGNOSTICS FOR FUEL SYSTEM - SERVICE TIPS |
04-23-03 (9 KB) |
| | | | X | X | X |
| DRIVE-AWAY SHUDDER OR VIBRATION |
04-22-07 (9 KB) |
X | X | X | X | X | X | X |
| MALFUNCTION INDICATOR LAMP (MIL) ON WITH MISFIRE DTC'S - SPARK KNOCK - PISTON SCUFFING |
04-22-01 (7 KB) |
| | | | | | X |
| TORQSHIFT TRANSMISSION AND PTO OPERATION - PTO LINE PRESSURE INSUFFICIENT - POSSIBLE TRANSMISSION DAMAGE |
04-20-10 (7 KB) |
| | | | | | X |
| LOW POWER - COLD SIDE CHARGE AIR COOLER (CAC) DISCONNECTED - OIL LEAK AT COLD SIDE CAC CONNECTIONS - 6.0L ENGINE - VEHICLES BUILT 12/15/2003 THROUGH 4/1/2004 |
04-20-09 (7 KB) |
| | | | | X | |
| INTERIOR PLASTIC TRIM - PAINT-TO-MATCH AND REPAIR - INTERIOR SPRAY PAINT AND ADHESION PROMOTOR USAGE INSTRUCTIONS |
04-20-07 (11 KB) |
| | | | | X | X |
| OIL LEAK - TURBO PEDESTAL SEAL AT EXHAUST BACK PRESSURE ACTUATOR (EBP) - 7.3L DIESEL |
04-20-02 (55 KB) |
X | X | X | X | X | | |
| WATER-IN-FUEL (WIF) LAMP |
04-19-04 (6 KB) |
| | | | X | X | |
| ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS - SERVICE TIPS |
04-18-15 (22 KB) |
X | X | X | X | X | X | X |
| BODY-CORROSION AT BOTTOM OF DOOR OR TAILGATE HEM FLANGE - REPAIR PROCEDURE |
04-18-11 (11 KB) |
X | X | X | | | | |
| DRIVEABILITY - NO START OR CONSTANT ENGINE MISFIRE - FUEL INJECTION CONTROL MODULE (FICM) DIAGNOSIS - 6.0L DIESEL |
04-18-06 (112 KB) |
| | | | X | X | |
| AXLE - FRONT HUBS NOT ENGAGING, NOT STAYING ENGAGED AND/OR UNLOCKING |
04-18-05 (58 KB) |
X | X | X | X | X | X | |
| TURBO-INDUCED EXHAUST MOAN/DRONE AT 1600-1800 RPM - 6.0L BUILT AFTER 9/29/2003 |
04-18-04 (59 KB) |
| | | | | X | |
| HARD START OR NO START - GPCM CONNECTOR SERVICE KIT AVAILABLE - 6.0L ENGINE |
04-17-13 (7 KB) |
| | | | X | X | |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINIATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS |
04-17-04 (13 KB) |
| X | X | X | X | X | |
| HIGH ENGINE RPM BETWEEN DOWNSHIFTS - LACK OF ENGINE BRAKING - 5.4L ENGINE AND MANUAL TRANSMISSION |
04-16-05 (6 KB) |
| | | | | X | |
| REAR AXLE POPPING/CHATTER NOISE - DANA 80 MODEL DUAL REAR WHEEL (DRW) |
04-16-04 (44 KB) |
X | X | X | X | X | X | |
| ENGINE MISFIRE OR ROUGH RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS |
04-16-01 (159 KB) |
X | X | X | X | X | X | X |
| OVERHEAD TRIP COMPUTER (OTC) DISTANCE TO EMPTY (DTE) INCORRECT |
04-15-10 (11 KB) |
| | | | X | X | |
| FRONT END ACCESSORY DRIVE (FEAD) BELT NOISE - VEHICLES BUILT PRIOR TO 6/1/2004 - 6.0L ENGINE |
04-14-12 (6 KB) |
| | | | X | X | |
| 6.0L ENGINE - LOW RPM, BUCK/JERK, MISS, STUMBLE - AFTER DECELERATION DOWN LONG GRADE WITH THE CRUISE CONTROL ENGAGED |
04-13-08 (7 KB) |
| | | | | X | |
SUSPENSION - VEHICLE SWAY/LEAN DURING LOW SPEED TURNING MANEUVERS
NOISE - SUSPENSION - POPPING NOISE IN FRONT END |
04-11-02 (41 KB) |
| | X | X | X | X | |
| BODY - PAINT - IRON PARTICLE REMOVAL - INDUSTRIAL FALLOUT - ACID RAIN NEUTRALIZATION |
04-09-06 (11 KB) |
| | | | | X | X |
ENGINE - EXHAUST - TURBO-INDUCED EXHAUST MOAN/DRONE AT 1600-1800 RPM - 6.0L BUILT PRIOR TO 9/29/2003
NOISE - VIBRATION - TURBO-INDUCED EXHAUST MOAN/DRONE AT 1600-1800 RPM - 6.0L BUILT PRIOR TO 9/29/2003 |
04-09-04 (61 KB) |
| | | | X | X | |
DRIVEABILITY - RUNS ROUGH AND/OR LOW POWER - 6.0L DIESEL ENGINE ONLY
ENGINE - FUEL IN OIL - 6.0L DIESEL - INJECTOR DIAGNOSIS |
04-09-03 (155 KB) |
| | | | X | X | |
DRIVEABILITY - WATER-IN-FUEL LAMP ILLUMINATED AFTER DRAINING HEATED FUEL CONDITIONING MODULE (HFCM) - VEHICLES BUILT PRIOR TO 11/1/2003 - 6.0L ENGINE
ENGINE - FUEL SYSTEM - WATER-IN-FUEL LAMP ILLUMINATED AFTER DRAINING HEATED FUEL CONDITIONING MODULE (HFCM) - VEHICLES BUILT PRIOR TO 11/1/2003 - 6.0L ENGINE |
04-09-02 (117 KB) |
| | | | X | X | |
| ENGINE - 7.3L DIESEL DI - HIGH PRESSURE OIL PUMP LEAK |
04-04-04 (61 KB) |
X | X | X | X | X | | |
| TRANSMISSION - 4R70W - NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - SERVICE TIP |
03-26-01 (93 KB) |
X | X | X | X | X | | |
| BODY - MIRROR - EXTERIOR MIRROR GLASS AND MOTOR REPLACEMENT - SERVICE TIPS |
03-23-02 (418 KB) |
X | X | X | X | X | X | |
NOISE - DRIVESHAFT CENTER BEARING NOISE - VEHICLES BUILT AFTER 6/1/2002
DRIVESHAFT - DRIVESHAFT - DRIVESHAFT CENTER BEARING NOISE - VEHICLES BUILT AFTER 6/1/2002 |
03-22-02 (41 KB) |
| | | X | X | | |
DRIVEABILITY - LOSS OF POWER AND EXTERNAL TURBO OIL LEAK - 7.3L DIESEL
ENGINE - 7.3L DIESEL - LOSS OF POWER AND EXTERNAL TURBO OIL LEAK
NOISE - EXHAUST NOISE FROM TURBO - 7.3L DIESEL |
03-21-49 (72 KB) |
X | X | X | | | | |
DRIVEABILITY - P0340 CAMSHAFT POSITION SENSOR FALSE DIAGNOSTIC TROUBLE CODE - VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE ONLY
TRANSMISSION - 4R100 - DELAYED 3-4 SHIFT - VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE ONLY |
03-21-48 (31 KB) |
| | | X | | | |
| ENGINE - 7.3L - OIL PAN CORROSION - SERVICE TIP |
03-21-46 (7 KB) |
X | X | X | X | X | | |
| ENGINE - 7.3L - EXTERNAL OIL LEAK DIAGNOSIS FOR 7.3L DIT ENGINES |
03-21-45 (7 KB) |
X | X | X | X | X | | |
NO START - STARTER MOTOR GEAR TEETH DAMAGE - VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE - MEXICO PRODUCED VEHICLES ONLY
ENGINE - 7.3L DIESEL - NO START - STARTER MOTOR GEAR TEETH DAMAGE - MEXICO PRODUCED VEHICLES ONLY
NOISE - STARTER MOTOR GEAR TEETH DAMAGE - MEXICO PRODUCED VEHICLES ONLY |
03-21-44 (10 KB) |
X | X | X | | | | |
| ENGINE - 7.3L - LOW OIL PRESSURE - CUAUTITLAN BUILT VEHICLES ONLY - EQUIPPED WITH 7.3L POWER STROKE DIESEL ENGINE - ENGINE SERIAL NUMBERS (ESN) BETWEEN 5000000 AND 5008850 ONLY |
03-21-43 (94 KB) |
| | X | | | | |
LACK OF POWER - UNDER A LOAD, AT CRUISE OR ON ACCELERATION - VEHICLES EQUIPPED WITH 7.3L DIT ENGINE ONLY - PRODUCED BEFORE 11/25/2000 ONLY
ENGINE - 7.3L DIT - LACK OF POWER UNDER A LOAD, AT CRUISE OR ON ACCELERATION - VEHICLES PRODUCED BEFORE 11/25/2000 ONLY |
03-21-42 (8 KB) |
X | X | X | | | | |
DRIVEABILITY - NO START, LOSS OF POWER OR ROUGH IDLE - DURING EXTREME COLD WEATHER OPERATION - FUEL GELLING - VEHICLES EQUIPPED WITH 7.3L ENGINE
FUEL - NO START, LOSS OF POWER OR ROUGH IDLE - DURING EXTREME COLD WEATHER OPERATION - FUEL GELLING - VEHICLES EQUIPPED WITH 7.3L ENGINE |
03-21-41 (6 KB) |
X | X | X | | | | |
DRIVEABILITY - BUCK/SURGE FELT WITH SPEED CONTROL ENGAGED - 7.3L ENGINE ONLY
ELECRICAL - BUCK/SURGE FELT WITH SPEED CONTROL ENGAGED - 7.3L ENGINE ONLY
ELECTRICAL - SPEED CONTROL - BUCK/SURGE FELT WITH SPEED CONTROL ENGAGED - 7.3L ENGINE ONLY |
03-21-40 (33 KB) |
X | X | | | | | |
| ENGINE - 7.3L DIT - HIGH INJECTION CONTROL PRESSURE READINGS - ENGINES BUILT AFTER ENGINE SERIAL NUMBER 896812 |
03-21-38 (7 KB) |
X | X | | | | | |
| ROUGH IDLE - NEW TOOL FOR TESTING ROUGH IDLE - INJECTOR PERFORMANCE ANALYZER - SERVICE TIP |
03-21-37 (7 KB) |
X | X | | | | | |
| ENGINE - 7.3L DIESEL - GLOW PLUG CONTROL MODULE - VEHICLES WITH CALIFORNIA EMISSIONS - SERVICE TIP |
03-21-36 (615 KB) |
| X | | | | | |
IDLE - IDLE SPEED TOO LOW WHEN COLD - VEHICLES WITHOUT CRUISE CONTROL AND WITH 7.3L DIESEL ENGINE
ENGINE - 7.3L DIESEL - IDLE SPEED TOO LOW WHEN COLD - VEHICLES WITHOUT CRUISE CONTROL |
03-21-35 (30 KB) |
X | | | | | | |
LAMP - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - FALSE DIAGNOSTIC TROUBLE CODE (DTC) P1298 STORED IN MEMORY - VEHICLES BUILT THROUGH 4/12/1999 WITH 7.3L DIESEL ENGINE
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - FALSE DIAGNOSTIC TROUBLE CODE (DTC) P1298 STORED IN MEMORY - VEHICLES BUILT THROUGH 4/12/1999 WITH 7.3L DIESEL ENGINE |
03-21-34 (9 KB) |
X | | | | | | |
| ENGINE - 7.3L DIESEL - 1999 ENGINE CONTENT REVISIONS |
03-21-33 (303 KB) |
X | | | | | | |
| ROUGH IDLE - INJECTOR BORE SCUFFING DURING ENGINE BREAK-IN PERIOD - SERVICE TIP |
03-21-31 (6 KB) |
X | | | | | | |
ENGINE - 7.3L DIRECT INJECTION DIESEL - "CACKLING" NOISE HEARD WITH ENGINE WARM AND SLIGHTLY ABOVE IDLE
ENGINE - 7.3L DIRECT INJECTION DIESEL - "BUZZING" NOISE HEARD WITH KEY ON ENGINE OFF DURING FUEL PUMP CYCLING |
03-21-30 (6 KB) |
X | | | | | | |
| ENGINE - 7.3L DIT - 1998-99 ENGINE CONTENT REVISIONS - SERVICE TIP |
03-21-29 (8 KB) |
X | | | | | | |
| DRIVEABILITY - VARIOUS DRIVEABILITY CONDITIONS - 6.0L DIT ENGINE - VEHICLES BUILT BEFORE 9/29/03 - CALIBRATION UPDATE - RUNNING CHANGE |
03-20-12 (33 KB) |
| | | | X | X | |
DRIVEABILITY - FUEL SYSTEM - INJECTOR COMBUSTION SEAL - INSTALLATION PROCEDURE - SERVICE TIP - 6.0L ENGINE
ENGINE - FUEL SYSTEM - INJECTOR COMBUSTION SEAL - INSTALLATION PROCEDURE - SERVICE TIP - 6.0L ENGINE |
03-20-10 (22 KB) |
| | | | X | X | |
DRIVEABILITY - NO START/REPEAT STARTER FAILURE - REPEAT STARTER REPLACEMENT
ELECTRICAL - STICKING OR BINDING IGNITION LOCK CYLINDER BETWEEN START AND RUN
ENGINE - STARTING - STARTER STAYING ENGAGED AT START UP |
03-20-05 (10 KB) |
X | X | X | X | X | | |
| DRIVEABILITY - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DTC'S P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 |
03-20-03 (116 KB) |
X | X | X | X | X | | |
| BRAKES - BRAKE PULL - 4X4 F-250/350 AND 4X4 EXCURSION VEHICLES ONLY |
03-19-10 (76 KB) |
X | X | X | X | X | | |
| ELECTRICAL - REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS |
03-18-01 (17 KB) |
X | X | X | X | X | X | |
| STEERING - STEERING WHEEL FIGHT AFTER RIDING OVER BUMPS/RUTS |
03-17-04 (225 KB) |
X | X | X | X | X | X | |
| TRANSMISSION - NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS |
03-14-08 (11 KB) |
X | X | X | X | X | | |
SUSPENSION - 4X4 WHEEL HUB NON-ENGAGEMENT/DISENGAGEMENT
AXLE - 4X4 WHEEL HUB NON-ENGAGEMENT/DISENGAGEMENT |
03-14-03 (21 KB) |
| X | X | X | X | | |
BODY - WATER LEAK FROM ROOF OPENING PANEL - ROOF OPENING PANEL BINDS OR WILL NOT OPEN PROPERLY
NOISE - RATTLE FROM ROOF OPENING PANEL AREA |
03-11-10 (89 KB) |
| | | | X | | |
| ELECTRICAL - WIRING - SOLDERING AND CRIMPING REPAIRS - SERVICE TIPS |
03-11-06 (175 KB) |
X | X | X | X | X | | |
SUSPENSION - ON-VEHICLE FRONT INTEGRATED HUB/BEARING ROCKING END-PLAY MEASUREMENT
AXLE - ON-VEHICLE FRONT INTEGRATED HUB/BEARING ROCKING END-PLAY MEASUREMENT |
03-11-02 (212 KB) |
X | X | X | X | X | X | |
DRIVEABILITY - BI-FUEL CNG/LPG LOW FLOW INJECTOR SERVICE KIT WITHOUT COOLANT LOCK-OFF
DRIVEABILITY - CRANK NO START - BI-FUEL CNG/LPG VEHICLES - LOW FLOW INJECTOR SERVICE KIT WITHOUT COOLANT LOCK-OFF |
03-10-03 (53 KB) |
| X | X | | | | |
| DRIVEABILITY - ROUGH IDLE AND/OR HESITATION ON ACCELERATION - VEHICLES EQUIPPED WITH 5.4L OR 6.8L ENGINE ONLY |
03-09-11 (51 KB) |
| X | X | X | X | | |
| ENGINE - ENGINE OIL LEVEL INDICATOR MARKINGS - REPORTS OF LOW OIL LEVELS |
03-08-03 (17 KB) |
| | | X | X | | |
| DRIVEABILITY - BI-FUEL - OXYGEN SENSOR DIAGNOSTICS - HIGH OXYGEN SENSOR VOLTAGE READING |
03-06-06 (7 KB) |
X | | | | | | |
| ENGINE - CYLINDER HEAD DECK LEAK - 4.6 AND 5.4L ENGINES - NEW "SERVICE ONLY" GASKET AND CYLINDER HEAD KITS AVAILABILITY |
03-06-02 (331 KB) |
X | X | X | | | | |
DRIVEABILITY - "WAIT TO START" LAMP DOES NOT OPERATE PROPERLY
ELECTRICAL - LAMP - "WAIT TO START" LAMP DOES NOT OPERATE PROPERLY |
03-04-05 (303 KB) |
| | | X | X | | |
| FRONT LOCKING HUBS - SERVICE TIP |
03-04-01 (9 KB) |
X | X | X | X | X | | |
| BODY - PAINT - NO CLEARCOAT BLENDING - COLLISION MANUAL CHANGE |
03-03-07 (6 KB) |
| | | X | X | | |
| ENGINE - 6.0L DIESEL - AIR FILTER SERVICE, REMOVAL OR REPLACEMENT - SERVICE TIPS |
03-01-09 (278 KB) |
| | | | X | | |
| ELECTRICAL - CDX6 RADIO DAMAGED DURING SERVICE SHIPPING - CORRECT SHIPMENT PROCEDURES FOR CDX6 RADIO - SERVICE TIPS |
02-25-02 (237 KB) |
| | X | X | X | | |
| COOLING SYSTEM - MOTORCRAFT PREMIUM GOLD ENGINE COOLANT - SERVICE TIPS |
02-23-07 (9 KB) |
| | | X | X | | |
| ENGINE - STRAIGHTEDGE PROCEDURE FOR CHECKING CYLINDER HEAD AND BLOCK FLATNESS |
02-21-13 (84 KB) |
X | X | X | X | X | | |
| TRANSMISSION - 4R100/E4OD - TORQUE CONVERTER ACCESS EXTERNAL DUST PLUG MAY BECOME DISLODGED |
02-21-01 (8 KB) |
X | X | X | X | X | | |
| CLIMATE CONTROL - A/C SERVICE TECH TIPS |
02-20-08 (18 KB) |
X | X | X | X | X | | |
| MOTORHOME GENERATORS - SHUT OFF WHEN FUEL TANK READS 1/4 FULL |
02-17-12 (156 KB) |
X | X | X | X | X | | |
| LAMP - BRAKE - INADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK |
02-17-06 (69 KB) |
X | X | X | X | X | | |
| BODY - PAINT - APPROVED PAINT MATERIALS FOR WARRANTY REPAIRS |
02-16-07 (525 KB) |
| | | | X | | |
FUEL SYSTEM - FUEL PUMP "WHINING"/"BUZZING" NOISE COMES THROUGH ENTERTAINMENT OR TWO-WAY RADIO SPEAKER
RADIO - ENTERTAINMENT OR TWO-WAY COMMUNICATION - "WHINING"/"BUZZING" NOISE IN SPEAKERS CAUSED BY FUEL PUMP
NOISE - "WHINING"/"BUZZING" - COMES THROUGH SPEAKERS OF ENTERTAINMENT OR TWO-WAY RADIO |
02-16-04 (99 KB) |
X | X | X | X | | | |
| PAINT - NEW POLISHING PRODUCTS - SERVICE PROCEDURES |
02-16-03 (108 KB) |
| | | X | X | | |
SUSPENSION - SQUEAK NOISE FROM REAR LEAF SPRINGS - REPLACEMENT REAR LEAF SPRING TIP LINER - VEHICLES PRODUCED BEFORE 10/15/01
NOISE - SQUEAK NOISE FROM REAR LEAF SPRINGS - REPLACEMENT REAR LEAF SPRING TIP LINER - VEHICLES PRODUCED BEFORE 10/15/01 |
02-14-01 (72 KB) |
X | X | X | X | | | |
| ENGINE - NEW GASKET REMOVER/CLEANER AND SERVICE TIPS FOR ALUMINUM HEADS AND BLOCKS |
02-11-04 (103 KB) |
X | X | X | X | | | |
ELECTRICAL - VEHICLE SPEED SIGNAL (VSS) INPUT NOTICED WHEN TESTING WITH NEW GENERATION STAR TESTER (NGS) WHEN VEHICLE IS STOPPED - SUPER DUTY F-53 MOTORHOME CHASSIS VEHICLES BUILT 1/2/1998 THROUGH 7/31/2000
TRANSMISSION - 4R100 - TRANSMISSION STARTS OUT IN 2ND GEAR - ERRATIC 1-2 UPSHIFT OR ERRATIC 2-1 DOWNSHIFT FROM TRANSMISSION - SUPER DUTY F-53 MOTORHOME CHASSIS VEHICLES BUILT 1/2/1998 THROUGH 7/31/2000 |
02-11-03 (101 KB) |
X | X | | | | | |
DRIVEABILITY - 5.4L 2V - IDLE-AIR BYPASS FLOW INDUCED WHISTLE
ENGINE - 5.4L 2V - IDLE-AIR BYPASS FLOW INDUCED WHISTLE
NOISE - IDLE-AIR BYPASS FLOW INDUCED WHISTLE - VEHICLES EQUIPPED WITH 5.4L 2V ENGINE ONLY |
02-10-08 (138 KB) |
X | X | X | X | | | |
| DRIVEABILITY - BI-FUEL LPG - CRANK NO START, ROLLING IDLE, SURGING IDLE, AND/OR SURGE AT CRUISE IN LPG MODE WITH ALT FUEL GREEN LIGHT ON |
02-10-04 (138 KB) |
| | X | X | | | |
| CLIMATE CONTROL - A/C COMING OUT DEFROST OR PERCEIVED A/C CURRING OUT ON LONG UPHILL GRADE |
02-07-02 (108 KB) |
| X | X | X | | | |
| SHEET METAL - PRIMED SERVICE PARTS - PREP PROCEDURE AND MSDS INFORMATION |
02-05-06 (286 KB) |
| | | X | | | |
BODY - "SQUEAK" OR BIND FROM TAILGATE
NOISE - "SQUEAK" OR BIND FROM TAILGATE |
02-03-05 (11 KB) |
X | X | X | X | | | |
DRIVEABILITY - LOW POWER CONDITION WHILE IN REVERSE GEAR - VEHICLES EQUIPPED WITH 6.8L 2V ENGINE, 4R100 TRANSMISSION AND PTO OPTION ONLY
TRANSMISSION - 4R100 - LOW POWER CONDITION WHILE IN REVERSE GEAR - VEHICLES EQUIPPED WITH 6.8L 2V ENGINE, 4R100 TRANSMISSION AND PTO OPTION ONLY |
02-02-01 (12 KB) |
| X | X | | | | |
| ENGINE - ENGINE OIL - RECOMMENDED APPLICATIONS FOR SAE 5W-20 AND SAE 5W-30 MOTOR OILS - GASOLINE AND FLEXIBLE FUEL VEHICLES ONLY |
02-01-09 (17 KB) |
X | X | X | X | | | |
| DRIVEABILITY - BI-FUEL - NO START IN ALT FUEL MODE - ALT FUEL SWITCH INDICATOR ON THEN OFF WHILE CRANKING - SOLENOID TANK VALVE COIL NOW AVAILABLE SEPARATELY FOR SERVICE |
02-01-08 (16 KB) |
| X | X | | | | |
| ENGINE - ENGINE OIL SYSTEM PRIMING PROCEDURES - SERVICE TIPS |
01-24-06 (7 KB) |
X | X | X | X | | | |
| CLUTCH - CLUTCH PEDAL STAYS ON FLOOR - NOT ABLE TO DISENGAGE CLUTCH - FLUID LEAK FROM HYDRAULIC CLUTCH LINE |
01-24-01 (8 KB) |
| | X | | | | |
ENGINE COOLANT - PROPYLENE GLYCOL - FORD MOTOR COMPANY POSITION ON ENGINE COOLANTS MADE FROM PROPYLENE GLYCOL
ENGINE COOLANT - PROPYLENE GLYCOL-BASED - FORD MOTOR COMPANY POSITOIN ON PROPYLENE GLYCOL-BASED ENGINE COOLANTS |
01-23-06 (7 KB) |
X | X | X | X | | | |
DRIVEABILITY - DIAGNOSTIC TROUBLE CODES (DTC) P0500, P1502 AND/OR U1039 CONTINENTAL MODELS ONLY - STICKING OR BINDING IGNITION LOCK CYLINDER - HIGH EFFORT WHEN TURNING IGNITION SWITCH
ELECTRICAL - STICKING OR BINDING IGNITION LOCK CYLINDER - HIGH EFFORT WHEN TURNING IGNITION SWITCH |
01-21-13 (25 KB) |
X | X | X | X | | | |
| DRIVEABILITY - BI-FUEL - LOCK-OFF SOLENOID AND SOLENOID TANK VALVE COIL RESISTANCE CHART - SERVICE TIPS |
01-21-04 (12 KB) |
X | X | X | | | | |
DRIVEABILITY - BI-FUEL WIRING CONNECTOR CROSS-REFERENCE CHART
ELECTRICAL - BI-FUEL WIRING CONNECTOR CROSS-REFERENCE CHART |
01-20-06 (8 KB) |
X | X | X | X | | | |
| ELECTRICAL - REVISED MECHANICAL HOOD LAMP SWITCH TO REPLACE OLD STYLE MERCURY HOOD LAMP SWITCH |
01-19-04 (5 KB) |
| X | X | | | | |
| VIBRATION - DRIVELINE DRONE OR VIBRATION - FELT AT 80-96 KM/H (50-60 MPH) - VEHICLES EQUIPPED WITH 228 INCH WHEELBASE AND 6.8L ENGINE ONLY |
01-17-03 (105 KB) |
X | X | X | X | | | |
CLIMATE CONTROL - REPEAT HEATER CORE FAILURE
COOLING SYSTEM - REPEAT HEATER CORE FAILURE |
01-15-06 (11 KB) |
X | X | X | X | | | |
| DRIVEABILITY - BI-FUEL VEHICLES ONLY - NO START - GASOLINE OR ALT FUEL MODE - VEHICLES EQUIPPED WITH 5.4L OR 6.8L BI-FUEL ENGINE ONLY |
01-15-05 (5 KB) |
X | X | X | | | | |
| DRIVEABILITY - BI-FUEL - NO START IN BI-FUEL MODE - ALT FUEL LIGHT ON - VEHICLES EQUIPPED WITH BI-FUEL ENGINE ONLY |
01-15-02 (6 KB) |
X | X | X | | | | |
| TRANSMISSION - 4R100 - DELAYED OR NO 2ND GEAR - DIAGNOSTIC TROUBLE CODES P0781, P0755 AND/OR P0756 - VEHICLES EQUIPPED WITH 4R100 TRANSMISSION WITH TRANSMISSION BUILD DATES BETWEEN 7/27/2000 AND 3/23/2001 ONLY |
01-13-05 (88 KB) |
| | X | | | | |
| ENGINE - OIL LEAK FROM RIGHT SIDE HEAD GASKET AREA - VEHICLS EQUIPPED EITH 4.6L/5.4L WINDSOR ENGINE ONLY - SERVICE TIPS |
01-12-02 (29 KB) |
X | | | | | | |
| WIRING - WIRE HARNESS TERMINAL REPAIR KIT AND WIRE SPLICE PROCEDURE |
01-10-12 (252 KB) |
X | X | X | X | | | |
| DRIVEABILITY - BI-FUEL COMPONENT IDENTIFICATION CHART - BI-FUEL ENGINES ONLY |
01-10-11 (66 KB) |
X | X | X | | | | |
| DRIVEABILITY - BI-FUEL - COMPUVALVE PRE-REPLACEMENT CHECK LIST - SERVICE TIPS |
01-10-06 (5 KB) |
X | X | X | | | | |
| ENGINE - 6.8L - OIL LEVEL INDICATOR READS INACCURATE - SUPER DUTY F-53 MOTORHOME CHASSIS VEHICLES - UPDATED OIL LEVEL INDICATOR |
01-10-05 (9 KB) |
X | X | X | | | | |
| DRIVEABILITY - BI-FUEL - PARAMETER IDENTIFICATION DATA (PID) INPUT AND OUTPUT INFORMATION - VEHICLES EQUIPPED WITH 5.4L OR 6.8L BI-FUEL ENGINE ONLY |
01-10-01 (21 KB) |
X | X | X | | | | |
| DRIVEABILITY - HO2S (HEATED OXYGEN SENSOR), CATALYST, AND FUEL SYSTEM MONITORS - SERVICE TIPS - OBD II VEHICLES ONLY |
01-09-07 (67 KB) |
X | X | X | | | | |
| DRIVEABILITY - BI-FUEL OBD II DIAGNOSTIC MONITOR APPLICATION STRATEGIES - BI-FUEL VEHICLES ONLY |
01-08-08 (5 KB) |
X | X | X | | | | |
| DRIVEABILITY - BI-FUEL - INTERMITTENT STARTING OR DRIVEABILITY WIRE HARNESS SERVICE TIPS - IN BI-FUEL OR GASOLINE MODE - BI-FUEL VEHICLES ONLY |
01-08-07 (4 KB) |
X | X | X | | | | |
| CLIMATE CONTROL - FACTORY INSTALLED A/C PREP PACKAGE COMPONENT IDENTIFICATION AND WARRANTY COVERAGE - F-53 SUPER DUTY CLASS A MOTORHOME CHASSIS VEHICLES ONLY |
01-07-05 (45 KB) |
X | X | X | | | | |
| DRIVEABILITY - BI-FUEL VEHICLE COMMUNICATION LINK (VCL) AND ALTERNATIVE FUEL CONTROL MODULE (AFCM) TERMINOLOGY CLARIFICATION - BI-FUEL VEHICLES ONLY |
01-07-04 (25 KB) |
| X | X | | | | |
ENGINE - 6.8L - "SQUEALING" NOISE FROM ENGINE COMPARTMENT - COMING FROM FRONT END ACCESSORY DRIVE (FEAD) BELT AREA - F-53 MOTORHOME CHASSIS VEHICLES BUILT 1/5/1998 THROUGH 7/18/1999 ONLY
NOISE - "SQUEALING" FROM ENGINE COMPARTEMENT - COMING FROM FRONT END ACCESSORY DRIVE (FEAD) BELT AREA - F-53 MOTORHOME CHASSIS VEHICLES BUILT 1/5/1998 THROUGH 7/18/1999 ONLY |
01-07-02 (4 KB) |
X | | | | | | |
DRIVEABILITY - BI-FUEL - HESITATION OR IDLE SURGE - HARD START, NO START OR START THEN STALL - WITH FUEL SELECTOR SWITCH LAMP ON IN BI-FUEL MODE - VEHICLES EQUIPPED WITH 5.4L/6.8L BI-FUEL ENGINE ONLY
DRIVEABILITY - BI-FUEL - HARD START, NO START OR START THEN STALL, HESITATION OR IDLE SURGE - WITH FUEL SELECTOR SWITCH LAMP ON IN BI-FUEL MODE - VEHICLES EQUIPPED WITH 5.4L/6.8L BI-FUEL ENGINE ONLY |
01-06-05 (8 KB) |
| X | | | | | |
| ELECTRICAL - TRAILER TOW WIRING - DIFFICULT TO LOCATE AT INSTRUMENT PANEL - VEHICLES BUILT 9/1/1999 THROUGH 10/4/2000 - RELOCATION PROCEDURE |
01-05-03 (62 KB) |
| X | X | | | | |
BRAKES - FRONT DISC BRAKE PAD AND/OR CALIPER RATTLE OVER BUMPS - REVISED FRONT BRAKE PADS
NOISE - RATTLE FROM FRONT DISC BRAKE PAD AND/OR CALIPER - REVISED FRONT BRAKE PADS |
01-04-09 (5 KB) |
| X | X | | | | |
| ENGINE - 5.4L - OIL SENDING UNIT INTERFERENCE FIT AT ENGINE OIL DRIP SHIELD - 4X4 VEHICLES EQUIPPED WITH 5.4L ENGINE ONLY |
01-04-02 (12 KB) |
X | X | X | | | | |
STEERING - WANDERING/STIFF STEERING OR POOR RETURNABILITY AFTER TURNS - 4X4 VEHICLES ONLY
SUSPENSION - WANDERING/STIFF STEERING OR POOR RETURNABILITY AFTER TURNS - 4X4 VEHICLES ONLY |
01-03-02 (8 KB) |
X | X | X | | | | |
DIAGNOSTIC TROUBLE CODES (DTCS) - P0350-P0360 COIL DTCS STORED IN MEMORY - ROUGH IDLE - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - COIL ON PLUG APPLICATIONS ONLY
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - ROUGH IDLE - DIAGNOSTIC TROUBLE CODES (DTCS) P0350-P0360 COIL DTCS STORED IN MEMORY - COIL ON PLUG APPLICATIONS ONLY
ROUGH IDLE - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0350-P0360 COIL DTCS STORED IN MEMORY
LAMP - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - ROUGH IDLE - DIAGNOSTIC TROUBLE CODES (DTCS) P0350-P0360 COIL DTCS STORED IN MEMORY - COIL ON PLUG APPLICATIONS ONLY |
01-01-06 (19 KB) |
| X | | | | | |
ENGINE - "MISS" NOISE FROM EXHAUST - UPDATED EXHAUST Y-PIPE AVAILABLE - VEHICLES EQUIPPED WITH 5.4L OR 6.8L ENGINE - BUILT THROUGH 9/10/2000
EXHAUST - "MISS" NOISE FROM EXHAUST - UPDATED EXHAUST Y-PIPE AVAILABLE - VEHICLES EQUIPPED WITH 5.4L OR 6.8L ENGINE - BUILT THROUGH 9/10/2000
NOISE - "MISS" NOISE FROM EXHAUST - UPDATED EXHAUST Y-PIPE AVAILABLE - VEHICLES EQUIPPED WITH 5.4L OR 6.8L ENGINE - BUILT THROUGH 9/10/2000 |
01-01-03 (14 KB) |
| X | X | | | | |
ENGINE - ROUGH IDLE/MISS AFTER START-UP DURING COLD AMBIENT TEMPERATURES LESS THAN -12 DEGREES C (10 DEGREES F) - VEHICLES BUILT 3/1/1996 THROUGH 7/31/2000
NOISE - FROM ENGINE - ROUGH IDLE/MISS AFTER START-UP DURING COLD AMBIENT TEMPERATURES LESS THAN -12 DEGREES C (10 DEGREES F) - VEHICLES BUILT 3/1/1996 THROUGH 7/31/2000 |
00-26-01 (27 KB) |
X | X | | | | | |
| TRANSMISSION - 4R100 - ERRATIC SHIFTING - EARLY AND/OR LATE SHIFTS - VEHICLES EQUIPPED WITH 6.8L ENGINE BUILT 1/12/1998 THROUGH 7/3/1999 ONLY |
00-24-06 (10 KB) |
X | X | | | | | |
| TRANSMISSION - 4R100 - FLUID OVERHEATS DURING SEVERE DUTY - AVAILABILITY OF UPDATED FLUID COOLER/FILTER KIT - VEHICLES PRODUCED BEFORE 2/6/2000 |
00-24-04 (5 KB) |
X | | | | | | |
| TRANSMISSION - FLUID IN-LINE FILTER KIT - REPEAT REPAIRS OF TRANSMISSION - SERVICE TIPS |
00-23-10 (8 KB) |
X | X | X | | | | |
STEERING - POWER STEERING PUMP BOLT - CORRECT PLACEMENT OF BOLTS AND WASHER - WINDSOR BUILT ENGINES ONLY
ENGINE - POWER STEERING PUMP BOLT - CORRECT PLACEMENT OF BOLTS AND WASHER - WINDSOR BUILT ENGINES ONLY |
00-22-02 (7 KB) |
| | X | | | | |
SUSPENSION - VIBRATION/SHAKE FELT IN STEERING WHEEL OR SEAT 72-120 KM/H (45-75 MPH)
VIBRATION - VIBRATION/SHAKE FELT IN STEERING WHEEL OR SEAT 72-120 KM/H (45-75 MPH) |
00-21-09 (81 KB) |
X | X | X | | | | |
| MIRRORS - SIDE VIEW SIGNAL MIRRORS - DELAMINATION OF SIGNAL MIRROR CHROME PLATING - MIRROR GLASS BLACK SPOTS |
00-18-09 (4 KB) |
X | | | | | | |
COOLING SYSTEM - COOLANT LEAK FROM PASSENGER SIDE OF INTAKE MANIFOLD AT REAR CORNER OF HEAD - VEHICLES BUILT FROM 7/1/1998 THROUGH 6/30/2000 - VEHICLES WITH 4.6L 2V OR 5.4L 2V ENGINE
ENGINE - 4.6L 2V OR 5.4L 2V - COOLANT LEAK FROM PASSENGER SIDE OF INTAKE MANIFOLD AT REAR CORNER OF HEAD - VEHICLES BUILT FROM 7/1/1998 THROUGH 6/30/2000 |
00-18-03 (9 KB) |
| X | | | | | |
| LEAK - TRANSMISSION FLUID LEAKS AT RADIATOR - VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSION AND TRANSMISSION OIL COOLER IN RADIATOR END TANK |
00-09-01 (27 KB) |
X | X | | | | | |
| BRAKES - PREMATURE REAR BRAKE PAD WEAR - SEVERE DUTY OPERATION - 17,500 LB F-550 AND ALL F-450 ONLY |
00-07-04 (26 KB) |
X | X | | | | | |
| CALIBRATION - RECALIBRATION OF POWERTRAIN CONTROL MODULES (PCMS) AFTER REPLACEMENT - SERVICE TIP - ALTERNATE FUEL VEHICLES ONLY |
00-06-11 (4 KB) |
| X | | | | | |
| SUSPENSION - FRONT STABILITY BAR MAY BREAK OFF - VEHICLES BUILT FROM 1/1/1998 |
00-01-06 (59 KB) |
X | | | | | | |
| FUEL ECONOMY - CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE |
99-26-09 (430 KB) |
X | X | | | | | |
BRAKES - GRABBING OR PEDAL KICKBACK
STEERING - INCREASED STEERING EFFORT
NOISE - "HISSING" HEARD WHILE APPLYING BRAKES |
99-25-08 (7 KB) |
X | | | | | | |
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0135, P0141, P0155, P0161, AND P0455 - NO DRIVEABILITY CONCERNS - VEHICLES WITH 5.4L ENGINE
LAMP - MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - DIAGNOSTIC TROUBLE CODES (DTCS) P0135, P0141, P0155, P0161, AND P0455 - NO DRIVEABILITY CONCERNS - VEHICLES WITH 5.4L ENGINE
POWERTRAIN CONTROL MODULE (PCM) - REPROGRAM - VEHICLES WITH 5.4L ENGINES |
99-25-03 (11 KB) |
| X | | | | | |
| NOISE - "THUMPING" FROM THE A/C SYSTEM DURING COLD ENGINE STARTUP = VEHICLES BUILT THROUGH 11/29/1999 |
99-24-06 (4 KB) |
X | X | | | | | |
| LOCKS - REPLACE AND/OR REPAIR ANY LOCK COMPONENT - AVAILABILITY OF INDIVIDUAL LOCKS |
99-24-02 (48 KB) |
X | X | | | | | |
| TRANSMISSION - 4R100 - FLEXPLATE REPLACEMENT - VEHICLES WITH 7.3L DIESEL ENGINE - SERVICE TIP |
99-23-06 (4 KB) |
X | | | | | | |
| MALFUNCTION INDICATOR LAMP (MIL) - DIAGNOSTIC TROUBLE CODES (DTCS) P0442 AND P0455 - NO DRIVEABILITY CONCERNS |
99-23-04 (13 KB) |
X | X | | | | | |
| AXLE - GAWR - INCREASING GAWR - SERVICE TIP |
99-23-02 (10 KB) |
X | | | | | | |
| TRANSMISSION - 4R100 - SERVICE PROCEDURE FOR ORANGE SERVICE TAGGED TRANSMISSION |
99-21-11 (11 KB) |
| X | | | | | |
| WHEELS - HUB CAPS FALLING OFF WHILE DRIVING - VEHICLES BUILT THROUGH 10/16/1999 |
99-21-02 (4 KB) |
X | | | | | | |
TRANSMISSION - M6OD - BROKEN/BENT SHIFT LEVER - VEHICLES WITH 7.3L DIESEL ENGINE
TRANSMISSION - M6OD - HARD SHIFTING - VEHICLES WITH 7.3L DIESEL ENGINE |
99-18-10 (13 KB) |
X | | | | | | |
NOISE - "SQUAKING" NOISE HEARD WHILE IN REVERSE BACKING UP - VEHICLES EQUIPPED WITH 5.4L OR 6.8L ENGINE
TRANSMISSION - 4R100 - "SQUAKING" NOISE HEARD WHILE IN REVERSE BACKING UP - VEHICLES EQUIPPED WITH 5.4L OR 6.8L ENGINE |
99-18-07 (10 KB) |
X | | | | | | |
TRANSMISSION - 4R100 - 3-4/4-3 SHIFT HUNT WHILE THE CRUISE CONTROL IS IN USE - VEHICLES WITH 7.3L DIESEL ENGINE
TRANSMISSION - 4R100 - NO 3-4 UPSHIFT WHILE THE CRUISE CONTROL IS IN USE - VEHICLES WIT 7.3L DIESEL ENGINE |
99-16-09 (9 KB) |
X | | | | | | |
IGNITION KEY - HARD TO REMOVE FROM IGNITION CYLINDER
IGNITION KEY - HARD TO TURN |
99-16-04 (71 KB) |
X | | | | | | |
SUSPENSION - FRONT LEAF SPRINGS - "SQUEAKING" NOISE HEARD WHILE DRIVING
NOISE - "SQUEAKING" NOISE HEARD FROM FRONT LEAF SPRINGS WHILE DRIVING |
99-16-03 (5 KB) |
X | | | | | | |
| TRANSMISSION - NEW TRANSMISSION FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA |
99-15-02 (4 KB) |
X | | | | | | |
| CALIBRATION INFORMATION - VEHCILES BUILT THROUGH 1/29/1999 - APPLICABLE ENGINES ARE 2.0L, 2.5L, 3.0L, 3.4L, 3.8L, 4.0L, 4.2L, 4.6L, 5.0L, 5.4L, 6.8L, AND 7.3L - SERVICE TIP |
99-14-07 (21 KB) |
X | | | | | | |
| SUSPENSION - REAR OF VEHICLE IS TOO HIGH/LOW - 5TH WHEEL AND GOOSE NECK APPLICATIONS - 4X4 VEHICLES BUILT THROUGH 2/14/1999 |
99-14-05 (168 KB) |
X | | | | | | |
| BRAKES - INNER REAR PAD - PREMATURE WEAR |
99-13-06 (40 KB) |
X | | | | | | |
| BRAKES - NEW DESIGN FRONT ROTOR AND HUB - INCLUDES VEHICLES WITH 4X4 - SERVICE TIP |
99-12-12 (4 KB) |
X | | | | | | |
NOISE - TSB SPECIAL FOR NOISE/VIBRATION/HARSHNESS
VIBRATION - TSB SPECIAL FOR NOISE/VIBRATION/HARSHNESS |
99-11-01 (1303 KB) |
X | | | | | | |
| INTERIOR TRIM - DOOR TRIM PANEL REPLACEMENT - SERVICE TIP |
99-08-15 (12 KB) |
X | | | | | | |
| TRANSMISSION - 4R100 - SHIFT FLARE (RISE IN ENGINE RPM) DURING 2-3 AND/OR 3-4 UPSHIFT - VEHICLES BUILT THROUGH 12/7/1998 WITH 7.3L DIESEL ENGINE |
99-08-01 (9 KB) |
X | | | | | | |
| TRANSMISSION - 4R100 - OIL-TO-AIR TRANSMISSION FLUID COOLER - SERVICE TIP |
99-07-04 (4 KB) |
X | | | | | | |
| WINDNOISE - AROUND SIDE DOOR(S) - SERVICE TIPS |
99-06-05 (38 KB) |
X | | | | | | |
| TRANSMISSION - CHECKING TRANSMISSION FLUID LEVEL COLD - SERVICE TIP |
99-05-03 (24 KB) |
X | | | | | | |
| REPROGRAMMING POWERTRAIN CONTORL MODULES (PCMS) - OUT-OF-VEHICLE - EEC V VEHICLES ONLY |
99-04-03 (6 KB) |
X | | | | | | |
BRAKES - ILLUMINATION OF RED BRAKE WARNING LAMP - BRAKE FLUID LEAK FROM REAR CALIPER - VEHICLES BUILT THROUGH 10/22/1998
BRAKES - INCREASED BRAKE PEDAL TRAVEL - BRAKE FLUID LEAK FROM REAR CALIPER - VEHICLES BUILT THROUGH 10/22/1998
BRAKES - SPONGY BRAKE PEDAL FEEL - BRAKE FLUID LEAK FROM REAR CALIPER - VEHICLES BUILT THROUGH 10/22/1998
LAMP - ILLUMINATION OF RED BRAKE WARNING LAMP - BRAKE FLUID LEAK FROM REAR CALIPER - VEHICLES BUILT THROUGH 10/22/1998 |
99-04-02 (5 KB) |
X | | | | | | |
NOISE - "RATTLING" NOISE FROM CONVERTER AREA - VEHICLES EQUIPPED WITH 4R100 TRANSMISSION AND 7.3L DIESEL ENGINE
TRANSMISSION - 4R100 - "RATTLING" NOISE FROM CONVERTER AREA - VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE |
99-03-05 (5 KB) |
X | | | | | | |
WATER LEAKS - WINDSHIELD SEALING - SERVICE TIP
WINDSHIELD - SEALING - SERVICE TIP |
99-02-03 (5 KB) |
X | | | | | | |
| CLUTCH - LOW CLUTCH PEDAL ENGAGEMENT - VEHICLES BUILT THROUGH 9/12/1998 WITH 7.3L ENGINE AND M6 TRANSMISSION |
99-01-06 (11 KB) |
X | | | | | | |
| FUEL - INFORMATION ON GASOLINE - TIPS TO RESOLVE VOLATILITY RELATED DRIVEABILITY CONCERNS |
98-26-02 (6 KB) |
X | | | | | | |
| INTERIOR TRIM - REPAIRS TO VINYL COVERED SURFACES - SERVICE TIP |
98-25-09 (6 KB) |
X | | | | | | |
| ELECTRICAL - NEW TERMINAL GREASE RELEASED FOR SERVICE |
98-24-06 (6 KB) |
X | | | | | | |
| SUSPENSION - FRONT OR REAR - SIDE-TO-SIDE LEVELING PROCEDURES AND ATTITUDE SERVICE KITS FOR F-53 RV BASIC STRIPPED CHASSIS |
98-23-21 (48 KB) |
X | | | | | | |
| MASS AIR FLOW (MAF) - SENSOR CONTAMINATION - SERVICE TIP |
98-23-10 (11 KB) |
X | | | | | | |
| AIR CONDITIONING - CONDENSATE DRIPS ONTO PASSENGER FLOOR |
98-23-08 (98 KB) |
X | | | | | | |
BRAKES - "WHISTLING" NOISE FROM HYDRO-MAX BRAKE BOOSTER ASSEMBLY - MOTORHOME CHASSIS VEHICLES
NOISE - "WHISTLING" FROM HYDRO-MAX BRAKE BOOSTER ASSEMBLY - MOTORHOME CHASSIS VEHICLES |
98-22-04 (4 KB) |
X | | | | | | |
| STEERING - STEERING WHEEL ALIGNMENT - CLEAR VISION - VEHICLES WITH MOTORHOME CHASSIS |
98-21-20 (39 KB) |
X | | | | | | |
| BRAKES - PARKING BRAKE CONTROL RUBBER BUMPER STOP - SERVICE PART NOW AVAILABLE |
98-21-17 (4 KB) |
X | | | | | | |
| POWER SEAT SWITCH - BUTTON COMES OFF |
98-20-19 (4 KB) |
X | | | | | | |
EXHAUST SYSTEM - LOOSE CATALYST OR MUFFLER HEAT SHIELDS
NOISE - "BUZZING" OR "RATTLING" - LOOSE CATALYST OR MUFFLER HEAT SHIELDS |
98-20-10 (37 KB) |
X | | | | | | |
NOISE - "TICKING" OCCURS ON INITIAL STARTUP WITH SHIFT SELECTOR IN "P" OR "N" POSITION - VEHICLES WITH E4OD/4R100 TRANSMISSION AND BUILT THROUGH 6/11/98
TRANSMISSION - E4OD/4R100 - "TICKING" NOISE OCCURS ON INITAL STARTUP WITH SHIFT SELECTOR IN "P' OR "N" POSITION - VEHICLES BUILT THROUGH 6/11/98 |
98-20-09 (7 KB) |
X | | | | | | |
| BODY - ADHESIVES NO RECOMMENDED FOR BODY PANEL REPAIRS - SERVICE TIP |
98-20-03 (7 KB) |
X | | | | | | |
AIR CONDITIONING - INOPERATIVE - VEHICLS BUILT THROUGH 7/30/98
AIR CONDITIONING - TEMPERATURE CONTOL INOPERATIVE - VEHICLES BUILT THROUGH 7/30/98
FUSE - FUSE #24 IN JUNCTION BLOCK OPEN |
98-19-03 (5 KB) |
X | | | | | | |
| BODY - TAILGATE MOULDING - WARPING |
98-17-23 (37 KB) |
X | | | | | | |
| SEAT - SEAT BACK RECLINER INOPERATIVE - MEMORY LATCH DOES NOT ENGAGE |
98-16-10 (4 KB) |
X | | | | | | |
| TRANSMISSION - E4OD/4R100 - 1989-99 - MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART |
98-16-08 (23 KB) |
X | | | | | | |
| AIR CONDITIONING - FILTERING REFRIGERANT AFTER A/C COMPRESSOR REPLACEMENT - SERVICE TIPS |
98-12-05 (21 KB) |
X | | | | | | |
| AXLE - FLUID LEAKS FROM REAR AXLE VENT TUBE - F-350, F-450 DRW VEHICLES BUILT THROUGH 3/2/98 AND F-450 MOTORHOME CHASSIS BUILT THROUGH 3/25/98 - VEHICLES EQUIPPED WITH 6.8L OR 7.3L ENGINE AND DANA MODEL 80 REAR AXLES |
98-11-10 (4 KB) |
X | | | | | | |
| TRAILER WIRING - CONVERTING A 4-WAY TRAILER CONNECTOR SYSTEM TO A 7-WAY HEAVY DUTY SYSTEM - SERVICE TIP |
98-08-10 (113 KB) |
X | | | | | | |
| MIRROR - TRAILER TOW MIRROR GLASS REPLACEMENT PROCEDURE |
98-07-07 (67 KB) |
X | | | | | | |
| LEAKS - OIL - AVAILABILITY OF NEW SILICONE GASKET AND SEALANT |
98-07-04 (4 KB) |
X | | | | | | |
