| ARTICLE TITLE |
ARTICLE NO. |
MODEL YEAR |
| 94 |
95 |
96 |
97 |
| Transmission/Clutch/Driveshaft/Axle |
| AXLE - 4X4 - "Ratcheting" Noise - Self-Engagement Of Automatic Hub Locks - F-250 And F-350 Over 8500# GVW |
97-06-27 (79 KB) |
|
X |
X |
X |
| AXLE - Leaks - Hub Seal Leak - Vehicles With Ford Design Full Floating 10.25 Inch (260mm) Axles |
94-19-24 (17 KB) |
X |
|
|
|
| AXLE - Lubricant Leaking From Rear Axle Seal(s) - Sub-Zero Temperatures - Vehicles With 10.25 Inch Ring Gear Full-Floating Rear Axle |
98-05A-27 |
|
X |
X |
X |
| CLUTCH - Clutch Does Not Disengage - Leaking Clutch Slave Cylinder - All Diesel Engine Vehicles |
95-04-09 (5 KB) |
X |
X |
|
|
| CLUTCH - Hard To Disengage Or Frequent Replacement Of Clutch Slave Cylinder - Early Wear-Out Of Slave Cylinder |
97-22-17 (4 KB) |
X |
X |
X |
X |
| DRIVELINE - "Clunking" Or "Grunting" Noise During Acceleration Or Stopping - 4X4 - 1992-96 F-150/F-250 Under 8500 Gross Vehicle Weight (GWV) And 1992-95 F-250/F-350 Over 8500 GVW |
96-23-20 (5 KB) |
X |
X |
|
|
| DRIVELINE - "Moan" - From Driveline At 1400-1700 RPM - F-350 Crew Cab 4X4 Vehicles With E4OD Transmission Only |
95-09-11 |
|
X |
|
|
| DRIVELINE - Vibration/Noise - When Driving In 4X2 Mode With Hubs Locked - 4X4 Models |
97-13-22 (41 KB) |
X |
X |
X |
X |
| E4OD - Separator Plate Identification - Service Tip |
94-18-12 |
|
X |
|
|
| FLUID - New Rotunda Fluid Changer - Service Tip |
95-16-10 |
X |
X |
X |
X |
| FLUID - Transmission Fluid Usage Charts |
01-15-07 |
X |
X |
X |
X |
| TORQUE CONVERTER - Leak Test Procedure - Service Tip |
96-24-09 (34 KB) |
X |
X |
X |
X |
| TRANSAXLE - Torque Converter Replacement Guidelines And Torque Converter/Transaxle Cooling System Cleaning Procedures - Service Tip |
96-26-12 (9 KB) |
X |
X |
X |
X |
| TRANSMISSION - All - Vehicle Can Be Shifted Out Of "Park" Without Depressing Brake Pedal - Econoline Cutaways Only And F-Series Built Through 2/28/95 |
96-08-18 (14 KB) |
X |
X |
|
|
| TRANSMISSION - C6, E4OD, AOD, 4R70W - Low Transmission Fluid Level And/Or Shift And/Or Engagement Concerns - 4X4 And AWD Vehicles Only |
97-12-13 (5 KB) |
X |
X |
X |
X |
| TRANSMISSION - E4OD - "Do Not Service" Tag Providing Special Contact Instructions Before 12/1/94 - Vehicles With 5.8L Gas Or 7.3L Diesel Engines |
94-06-17 (58 KB) |
X |
|
|
|
| TRANSMISSION - E4OD/4R100 - 1989-99 - Main Controls, Separator Plates And Separator Plate Gaskets Usage Chart |
98-16-08 (23 KB) |
X |
X |
X |
X |
| TRANSMISSION - E4OD - 7.3L DIT Engine - Overdrive Cancel Lamp Illuminated And Diagnostic Trouble Code (DTC) P1728 - Vehicles Built Prior To 9/20/95 |
96-10-14 |
|
X |
X |
|
| TRANSMISSION - E4OD - 7.3L DIT Engine - Overdrive Cancel Lamp Illuminated, Diagnostic Trouble Code (DTC) P1728, And When Reverse And/Or Manual Low Are Selected - Vehicles Built Prior To 9/20/95 |
96-10-14 |
|
X |
X |
|
| TRANSMISSION - E4OD - Delayed Forward Engagement And/Or Heat Stained Forward Clutch Plates After Installing Center Support Service Kit F4TZ-7A130-B |
95-11-13 (30 KB) |
X |
|
|
|
| TRANSMISSION - E4OD - Diagnostic Trouble Codes - Water Intrusion Of The MLP/TR Sensor |
95-02-12 (5 KB) |
X |
|
|
|
| TRANSMISSION - E4OD - Direct Clutch Plate Usage Chart - Service Tip |
95-25-13 |
X |
X |
X |
|
| TRANSMISSION - E4OD - Engine Stall During Engagement |
97-24-23 |
|
|
X |
X |
| TRANSMISSION - E4OD - Excessive Bushing Wear - Low One-Way Clutch Malfunction |
94-23-18 (945 KB) |
X |
|
|
|
| TRANSMISSION - E4OD - Flashing Transmission Control Indicator Lamp (TCIL) With Diagnostic Trouble Codes (DTCs) 62, 628 And/Or 1728 Stored In Memory |
98-04-19 (6 KB) |
X |
X |
X |
X |
| TRANSMISSION - E4OD - Fluid Level Indicator Damaged On Vehicles Built Through 2/10/94 With A 7.3L Indirect Injection Turbo Diesel |
94-16-21 (3 KB) |
X |
|
|
|
| TRANSMISSION - E4OD - Forward Clutch Wear |
94-23-18 (945 KB) |
X |
|
|
|
| TRANSMISSION - E4OD - Forward/Reverse Sun Gear Service Information |
94-05-15 |
X |
|
|
|
| TRANSMISSION - E4OD - Harsh Shifts - F-250-350, E-350, And Cutaway Equipped With 7.3L Diesel Engine Built Between 5/15/96 And 7/8/96 - California Calibration 6-90P-R11 Only |
96-21-16 |
|
|
X |
|
| TRANSMISSION - E4OD - Harsh/Delayed 2-3 Upshifts - Vehicles With 7.3L Diesel And 49-State Calibration - F-Series Built Through 2/3/97 And All 1996 E-350 |
97-06-29 |
|
|
X |
X |
| TRANSMISSION - E4OD - Heat Stained Overdrive Planetary Gearset, Coast Clutch Cylinder Bushing And/Or Overdrive Cylinder Bushing |
95-21-09 (17 KB) |
|
X |
|
|
| TRANSMISSION - E4OD - Intermediate Brake Drum Assembly Usage - Service Tip |
95-16-19 (3 KB) |
X |
X |
|
|
| TRANSMISSION - E4OD - New Design Elastomeric Gaskets For Main Control Cover And Bottom Pan |
96-03-22 (4 KB) |
|
|
X |
|
| TRANSMISSION - E4OD - New Design Intermediate Band Apply Servo Assembly |
95-23-14 (9 KB) |
X |
X |
X |
|
| TRANSMISSION - E4OD - New Design Overdrive Clutch Piston Assembly For Some 1996-97 Vehicles - Vehicles Built From 12/5/95 Through 6/15/96 |
96-21-15 |
|
|
X |
X |
| TRANSMISSION - E4OD - New Design Reverse Clutch Assembly - Transmission Built From 3/26/97 |
97-17-25 (46 KB) |
|
|
|
X |
| TRANSMISSION - E4OD - New Design Transmission Range Sensor (TR) And Connector Included With All E4OD Remanufactured Transmissions |
95-06-19 (69 KB) |
X |
|
|
|
| TRANSMISSION - E4OD - Orange Tag On Transmission Pan - "Do Not Service" - Service Procedures |
94-16-22 (13 KB) |
X |
|
|
|
| TRANSMISSION - E4OD - Overdrive On-Way Clutch - Service Tips |
95-06-18 (3 KB) |
X |
X |
|
|
| TRANSMISSION - E4OD - Overheating - Converter Cover Discoloration, Clutches Burned, Burnt Fluid |
94-23-18 |
X |
|
|
|
| TRANSMISSION - E4OD - Possible Water Intrusion Into The MLP/TR Sensor Causing Shift Concerns And/Or Harsh Engagement Concerns |
95-02-12 (5 KB) |
X |
|
|
|
| TRANSMISSION - E4OD - Reverse Clutch Piston And Piston Seal Usage - Service Tip |
96-07-28 (5 KB) |
X |
X |
X |
|
| TRANSMISSION - E4OD - Revised Design Forward Planet Thrust Washer - Service Tip |
96-24-18 (51 KB) |
|
|
X |
X |
| TRANSMISSION - E4OD - Revised Rear Case Bushing |
95-11-12 |
X |
X |
|
|
| TRANSMISSION - E4OD - Rotunda Transmission Tester Overlay Cable 007-00107 - Service Tip |
95-01-10 |
|
X |
|
|
| TRANSMISSION - E4OD - Service Case Replacement Service Tips For 7.3L Diesel Vehicle Applications |
98-13-21 (21 KB) |
X |
X |
|
|
| TRANSMISSION - E4OD - Service Information For Orange-Tagged Transmissions |
94-18-11 (12 KB) |
|
X |
|
|
| TRANSMISSION - E4OD- Shift Concerns And/Or Harsh Engagement Concerns Due To Water Intrusion Of The MLP/TR Sensor |
95-02-12 (5 KB) |
X |
|
|
|
| TRANSMISSION - E4OD - Torque Converter Making Dragging Or Scraping Noise During Assembly - Vehicles With 7.3L Direct Injection Turbo Diesel - Service Tips |
94-21-15 |
|
X |
|
|
| TRANSMISSION - E4OD - Unique Overdrive Ring Gear, One Way Clutch Retaining Ring And Shaft Retaining Ring - Service Tip |
96-21-17 |
|
X |
X |
|
| TRANSMISSION - E4OD - Upgrade - Ball Bearing Center Support Service Kit |
94-24-15 (129 KB) |
X |
|
|
|
| TRANSMISSION - E4OD - Upgraded Components To Be Installed During Teardown |
94-23-18 (945 KB) |
X |
|
|
|
| TRANSMISSION - E4OD - Upgraded Overdrive Planet Assembly And Input Shaft When Replacement Of Either Becomes Necessary |
94-21-13 (22 KB) |
X |
|
|
|
| TRANSMISSION - E4OD - Vehicle Does Not Move - Diagnosis And Service Tips |
94-21-14 (26 KB) |
X |
X |
|
|
| TRANSMISSION - E4OD And C6 - Installation Instructions For "New Unitized Plastic Cage" Low One-Way Clutch - 1989-94 Models With E4OD And All Model Years With C6 |
94-08-20 (40 KB) |
X |
|
|
|
| TRANSMISSION - E4OD And C6 - No Forward Engagement - Service Tips For Installing "New Unitized Plastic Cage" Low One-Way Clutch - 1989-94 Models With E4OD And All Model Years With C6 |
94-08-20 (40 KB) |
X |
|
|
|
| TRANSMISSION - Torque Converter Replacement Guidelines And Torque Converter/Transmission Cooling System Cleaning Procedures - Service Tip |
96-26-12 (9 KB) |
X |
X |
X |
X |
| TRANSMISSION - ZF - Loctite Sealant Usage - Vehicles Built From 2/2/94 |
94-17-13 |
X |
|
|
|
| TRANSMISSION - ZF Manual - Use Of Synthetic Mercon Transmission Fluid, Service Tips - Vehicles With 7.3L Direct Injection Diesel Engine Built After 2/2/94 |
94-08-19 |
X |
|
|
|
