Nice job. How long does the 8 Gallons last you? So the low boost side sprays at 5 lbs of boost?
DIY Water/Meth kit
Thought I would throw a post together for the “do it yourselfer.”
Here is my DIY 2 stage Water/Methanol kit I put together for around $382.00
*If you just want a simple 1 stage kit this setup would cost about $280
Parts:
Pump- (1) Shurflo 150-180PSI/1.5GPM purchased on “Ebay” from seller “Alcohol injection systems.com” $89.00
Water Tank- (1) Northerntool.com Snyder Industries Horizontal Sprayer Tank 8 Gallon Capacity, Model# 10282 $59.99
Water Solenoids- (2) McMaster.com part # 7876K12 $41.24each
Filter- (1) 3/8” fuel filter “Autozone” $4.00
Hobbs Switch- (2) Picked up two of these at local automotive store. $30each
Brass fittings-
(9) 3/8” thread to 3/8” brass barb fittings
(2) 3/8” brass “T” fittings
(2) 1/8” brass 90* fittings
(2) 1/8” thread to 5/16” brass barb fittings
(1) 90* plastic 3/8” barb fitting for tank feed
Total- $40.00
Nozzles- McMaster.com $4.65each
I wasn't sure which nozzles to buy so I bought almost all of them to try different ones out.
(1)Part # 3178K75 [email protected]
(1)Part # 3178K76 [email protected] *This is my high boost
(1)Part # 3178K77 [email protected]Hose- 3/8” ID 220PSI hose from LOWES $.55per/ft got about 20ft Total- $11.00
14-16 gauge wire for switches, lights and solenoids.
Assorted electrical connectors, fuse holder
Total about $30.00
Pictures:
![]()
Here is the schematic I drew up.
![]()
The two switches and two lights above my 4x4 cutout are for the Water/Meth.
Left to Right-
System on for low boost, Low boost active light, System on for high boost, High boost active light.
![]()
8Gal Tank in toolbox.
![]()
Pump placement under passenger side door on frame.
Here is my DIY 2 stage Water/Methanol kit I put together for around $382.00
*If you just want a simple 1 stage kit this setup would cost about $280
Parts:
Pump- (1) Shurflo 150-180PSI/1.5GPM purchased on “Ebay” from seller “Alcohol injection systems.com” $89.00
Water Tank- (1) Northerntool.com Snyder Industries Horizontal Sprayer Tank 8 Gallon Capacity, Model# 10282 $59.99
Water Solenoids- (2) McMaster.com part # 7876K12 $41.24each
Filter- (1) 3/8” fuel filter “Autozone” $4.00
Hobbs Switch- (2) Picked up two of these at local automotive store. $30each
Brass fittings-
(9) 3/8” thread to 3/8” brass barb fittings
(2) 3/8” brass “T” fittings
(2) 1/8” brass 90* fittings
(2) 1/8” thread to 5/16” brass barb fittings
(1) 90* plastic 3/8” barb fitting for tank feed
Total- $40.00
Nozzles- McMaster.com $4.65each
I wasn't sure which nozzles to buy so I bought almost all of them to try different ones out.
(1)Part # 3178K61 [email protected] *This is my low boost
(1)Part # 3178K62 [email protected](1)Part # 3178K75 [email protected]
(1)Part # 3178K76 [email protected] *This is my high boost
(1)Part # 3178K77 [email protected]
Total- $23.25
Electrical-
(1) Automotive relay SPST “Radioshack” Model: 275-001 Catalog #: 275-001 $6.00
(1)Green led “Radioshack” Model: 276-271 Catalog #: 276-271 $1.99
(1)Red led “Radioshack” Model: 276-270 Catalog #: 276-270 $1.99
(2) SPST Submini toggle switch “Radioshack” Model: 275-612 Catalog #: 275-612 $2.99each
12 gauge wire for pump14-16 gauge wire for switches, lights and solenoids.
Assorted electrical connectors, fuse holder
Total about $30.00
Pictures:
Here is the schematic I drew up.
The two switches and two lights above my 4x4 cutout are for the Water/Meth.
Left to Right-
System on for low boost, Low boost active light, System on for high boost, High boost active light.
8Gal Tank in toolbox.
Pump placement under passenger side door on frame.
4
1 - 2 of 12 Posts
So is there a noticeable difference while driving around town at the 5lbs of boost? Smoother? Quiter? More Power? I also hear some guys running 100% water to just lower egt's and some have also said the 6.0 can't take as much methanol as some of the other motors.
Mike
p.s. My race boat runs on 100% Methanol
Mike
p.s. My race boat runs on 100% Methanol
1 - 2 of 12 Posts
